Albany UltraSmart Service Manual

UltraSecure 3000 with UltraSmart Owners Manual Doors are UltraRugged, UltraReliable, UltraAffordable. Albany Door Systems - A Company of Albany Int

9 Manual #001451 Version 4.2 Before checking the following mentioned components the cover in front of the spring housing and eventually the existin

Rev. 9/27/2009 Manual #001451 10 Operation High Speed Doors Safety Instructions Area of Application and Classified Use Unless explicitly described

11 Manual #001451 Version 4.2 General Safety Advice Please read the user manual carefully and keep it easily accessible for future use. Always foll

Rev. 9/27/2009 Manual #001451 12 Operation High Speed Doors Troubleshooting To avoid damage to the door or injury to personnel during repair of m

13 Manual #001451 Version 4.2 Electrical Malfunctions For repair of electrical malfunctions see the error code manual at the appendix of the user m

Rev. 9/27/2009 Manual #001451 14 Operation High Speed Doors Inspection and Maintenance Maintenance and inspection work must only be per-formed by

15 Manual #001451 Version 4.2 Controls Figure 1 Control Panel Key This key pad opens the door and stops the delay timer from closing the door. This

Rev. 9/27/2009 Manual #001451 16 Operation High Speed Doors Control Panel Display The display on the front of the control panel shows two lines of

17 Manual #001451 Version 4.2 Line One (1) Text Line Two (2) Text Startup: R-Bac Industries Door Not Ready Normal Operation: Door ready Open

Rev. 9/27/2009 Manual #001451 18 Operation High Speed Doors Adjustments Door Limit Adjustments Door limit adjustments are used to set four height

1 Manual #001451 Version 4.2 STATEMENT OF WARRANTY UltraSecure 3000 High Speed Doors ONE-YEAR WARRANTY ON MECHANICAL AND ELECTRICAL COMPONENTS Alb

19 Manual #001451 Version 4.2 Periodic Maintenance Continued… Quarterly Inspection 1. Perform daily inspection. 2. Check all mounting hardware an

Rev. 9/27/2009 Manual #001451 20 Operation High Speed Doors Trouble Shooting Continued... DISPLAY OR DOOR Problem Possible Cause Corrective Actio

21 Manual #001451 Version 4.2 Trouble Shooting Continued... Light Curtain Problem Possible Cause Corrective Action Red alarm LED on. Transmitter

Rev. 9/27/2009 Manual #001451 22 Operation High Speed Doors Trouble Shooting Continued... Motor Drive Fault Problem Possible Cause Corrective Act

23 Manual #001451 Version 4.2 MOTOR WIRING 6"¼”MOTOR WIRESDRILL ONLY INTO BOTTOM OF BOXUSE MINIMUM ¾” CONDUIT¾”MOTOR WIRE CONDUITSEPARATEFOIL

Rev. 9/27/2009 Manual #001451 24 Operation High Speed Doors ACTIVATION WIRING HMANUALACTIVATORS13456MODULE - ACONNECT AS “NORMALLY OPEN”2TB2REMOTE

25 Manual #001451 Version 4.2

Rev. 9/27/2009 Manual #001451 26 Operation High Speed Doors

27 Manual #001451 Version 4.2

Rev. 9/27/2009 Manual #001451 28 Operation High Speed Doors

Rev. 9/27/2009 Manual #001451 2 Operation High Speed Doors TABLE OF CONTENTS ALBANY DOOR SYSTEMS CONTACT INFORMATION: Port Washington, WI 1080 M

29 Manual #001451 Version 4.2 ENABLING THE WIRELESS SAFETY SYSTEM If the door is equipped with Albany’s Wireless Safety System (indicated by the la

Rev. 9/27/2009 Manual #001451 30 Operation High Speed Doors UltraSmart™ STARTUP PROCEDURE Albany’s UltraSmart™ control system is designed to accomm

31 Manual #001451 Version 4.2 SETTING SYSTEM OPTIONS 1) Press and hold until ―LIMIT SETUP‖ is shown on the display; Press 2) Press until

Rev. 9/27/2009 Manual #001451 32 Operation High Speed Doors Instructions for Using Over-Travel Brake System. About the Over-Travel Brake System Yo

33 Manual #001451 Version 4.2 Resetting the Brake To reset the brake, first loosen the clamp screws (Fig 3) so that you can move the yoke up and do

Rev. 9/27/2009 Manual #001451 34 Operation High Speed Doors Electrical Operation Instructions When the over-travel mechanism has been engaged, the

35 Manual #001451 Version 4.2

Rev. 9/27/2009 Manual #001451 36 Operation High Speed Doors

37 Manual #001451 Version 4.2

Rev. 9/27/2009 Manual #001451 38 Operation High Speed Doors

3 Manual #001451 Version 4.2 INTRODUCTION The contents of this manual are designed to help you operate and maintain Albany UltraLite™, UltraFast™,

39 Manual #001451 Version 4.2

Rev. 9/27/2009 Manual #001451 40 Operation High Speed Doors

41 Manual #001451 Version 4.2

Rev. 9/27/2009 Manual #001451 42 Operation High Speed Doors

1080 Maritime Drive, Port Washington, WI 53074 Phone: (262) 268-9885 Fax: (262) 268-9895 albanydoors.com

Rev. 9/27/2009 Manual #001451 4 Operation High Speed Doors Product Description Principle The UltraSecure 3000 is a vertically opening high-speed r

5 Manual #001451 Version 4.2 Control Unit The UltraSecure 3000 is operated by a frequency converter control unit, which enables smooth ac-celeratio

Rev. 9/27/2009 Manual #001451 6 Operation High Speed Doors Mechanical Safety Devices Springs are situated in separate chambers serving as a weight

7 Manual #001451 Version 4.2 UltraSecure 3000 10’ high up to 16’ high

Rev. 9/27/2009 Manual #001451 8 Operation High Speed Doors UltraSecure 3000 up to 10’ high